Copper solvent extraction reagent, Nickel Cobalt extractant, DEHPA & Rare earth leaching solvent

In the extraction tower processing pesticide pollution wastewater containing phenol

by:Deyuan      2020-08-26
Phenol in waste water is industrial production one of high toxicity and refractory organic compounds, phenol wastewater not only pollute the environment seriously, cause the loss of the agriculture, fisheries, and endangering human health (1), treatment of wastewater containing phenol get extensive attention from all over the world. Treatment of wastewater containing phenol at home and abroad common methods mainly include physical, chemical method [3] and [2] of the biochemical method (4, 5) and the combination technology (6, 7), etc. A pilot plant is scientific research, production of chemical industrial base, the production of waste water containing phenol, benzene, xylene and other organic compounds and acidic waste water, considering the receiving waters is the agriculture irrigation streams, and factory is located in the county town, must be carried out on the discharge of waste water treatment. Works according to the characteristics of the wastewater, design a set of the level of anaerobic treatment, the secondary biological contact oxidation, biochemical reaction flocculation - Oxidation - Flocculation precipitation sewage treatment system, the early operation meet the design requirements, but because of the system running time is long, part of the aging equipment, especially the sludge ( Bacteria) Cultivation and domestication is bigger problems, processing system can not run normally, therefore, need the original sewage treatment system to conduct a comprehensive reform, to establish a system of anaerobic and aerobic sludge cultivation and domestication system, sewage system returned to normal operation, to achieve the design discharge standards.
the wastewater composition is complicated, mainly small molecules containing phenols, fatty acid, sebacic acid ester and glycerol and other organic pollutants, the other containing sodium sulfate and other inorganic salts, wastewater pH is low. Wastewater is high content of phenolic substances, recycling value engineering with the method of complexation extraction for enrichment of phenolic substances in wastewater recycling [2]. Other not extract the water extraction of the organic matter content is still high, at the same time due to the presence of high concentrations of sodium sulfate salt, organic pollutants is difficult to directly biochemical degradation, increasing the difficulty of wastewater treatment, waste water must be desalination processing. For actual desalting process, engineering often adopt the method of evaporation, it can achieve satisfactory result of desalination. Through the study of the evaporation process of extraction of water, recycling of sodium sulfate salt products; After the evaporation of condensate in the A/O biological treatment, so as to realize the wastewater discharging standard.
wastewater treatment process

( 1) Filter of high salt waste water containing phenol was isolated after adjusting the pH and complexation extraction agent according to certain proportion pump into the extraction tower, after full reaction under normal temperature static layering, extraction of the lower residual phase ( Extraction effluent) Into the evaporation system, the upper extraction phase ( Load extraction agent) Send back extraction regeneration system.
    ( 2) The extraction phase ( Load extraction agent) With lye pump by certain proportion into the back extraction tower, let stand layered after responding well under normal temperature, the lower of the extraction solution ( Sodium phenol solution) Recycling returns sebacic acid production system, the upper for regeneration after extraction agent, recycling use in extraction system.
    ( 3) More than the above extraction phase ( Extraction effluent) Pump into the three effect evaporator, continuous decompression evaporation, concentrate filtering crystallizing anhydrous sodium sulfate product, evaporation condensation water to send A/O biological system.
    ( 4) Evaporation condensation water after cooling, into the biochemical system adjusting pool, add sewage homogeneous, average, at the same time, wastewater pH regulation, and according to certain proportion to join nitrogen, phosphorus and other nutrients.
    ( 5) Will adjust pool mixture wastewater pump into the biochemical system A pool of oxygen biochemical treatment, A pool dosing through domestication, cultivation of microbial agents. The purpose of A pool of oxygen biochemical treatment is to reduce the relative molecular mass organic material, improve the efficiency of subsequent aerobic biochemical treatment.
    ( 6) After A pool of oxygen biochemical treatment of the sludge mixture into O pool to blast aeration stirring, control of dissolved oxygen, pH, temperature and other conditions for aerobic biochemical treatment. After A pool aerobic biochemical treatment of stratified mixture into the pond, subsidence, sedimentation sludge part back into A pool, part into the sludge thickener for enrichment settlement, the use of filter press filter cake after discharge, supernatant fluid into the flocculation reaction tank, adding flocculant flocculation sedimentation treatment, effluent standards.
Custom message
Chat Online
Chat Online
Chat Online inputting...
Please send email to jeven@metalleaching.com. Thanks.
Sign in with: